1. Site Description
2. Geology
3. Access
4. General Assessment:
5. Associated Sites
6. Safety Information
7. Supplementary Information
8. Industrial History and Archaeology
9. Bibliography
10. Maps
11. Surveyors

This page still under construction.

Site Description

Grid Reference: NZ 751 198 to 783 191
BGS Sheet: 34
OS Sheet: 94

Site Status: Heritage Coast (Not RIGS, other references Nos. 55 and 80). Open access.

Description of Geodiversity: West of Boulby the cliffs rise to over 200m O.D. with the upper parts being formed of the old Boulby and Loftus Alum Quarries. These are SSSIs and, also for access reasons, are described separately. Between Boulby and Cowbar can be found superb sea cliffs and rocky foreshore (scar) with extensive Lias Group exposures. Much historical and industrial archaeological interest. The Cleveland Way passes along the cliff top.

View of Cowbar Nab from Staithes Harbour showing beds of the Staithes Formation capped by glacial 'till'.

Geology

With shallow dips, the strata that can be examined directly in situ are limited to the uppermost beds of the Redcar Mudstone Formation and the base of the Staithes Sandstone Formation. In the past, there were tracks down the cliffs that enabled geologists to study the full section easily.

• Whitby Mudstone Formation: This forms the upper part of the sea cliffs at Boulby with the alum shale quarry at about 130m O.D.
• Cleveland Ironstone and Staithes Sandstone Formations: These form the main cliff faces.
• Redcar Mudstone Formation: This forms the base of the cliffs and the scar. It is part of the Ironstone Shale, the uppermost, informal sub-unit, and consists principally of sandy, silty shale with conspicuous ironstone and calcareous beds and nodule bands (some remarkably like cannon balls).

Geomorphology: The cliffs for about 2 km to the west of Cowbar Nab are capped by glacial till, bedrock being at 40 to 50m O.D. Staithes Beck has cut a deep channel through the till in to the solid strata. On the coast, several landslips and rockfalls can be seen and, in contrast, examples of slow, gradual marine erosion. The marine erosion has been the subject of detailed studies by Agar (1960) and by Durham University in recent years.

Historical geology: This is the site of 19^th century measured sections by Rev. George Young, John Phillips, Lewis Hunton and others.

Industrial Archaeology:

• The cliffs form the seawards edge of Main Seam (Cleveland Ironstone Formation) underground workings of Boulby and Grinkle Ironstone Mines.
• With regard to the alum industry, the landing place (dock) and tunnel (leading to a shaft up to the alum house) are at Hole Wyke (NZ 762 193).

Access

Access to the scar is achieved from the west side of Staithes harbour. Visitors should park in the car park at the top of Staithes Bank (NZ 781 185), follow Staithes Lane north for c.400m before crossing Staithes Beck by bridge (NZ 781 189), then follow the road east to Cowbar Nab.

It is imperative to start no less than 2 hours before low tide and when sea conditions are reasonably calm. Please read the safety information given below and check tide times before setting off.

Access map for Boulby - Cowbar Foreshore showing suggested parking in Staithes and Mean High Water along cliff base.
(Click on map to enlarge.)

General Assessment:

This coastal section is not recommended for general geological studies owing to the access problems. However, the scar at Cowbar Nab is easy to visit at low tide; it forms a small part of the Geologists’ Association Guide No. 34 by Rawson and Wright (locality 1A, page 18 in 3rd edition). It is adventurous to visit the unique alum tunnel (about 2 km to the west) but this must on no account be entered. Children are best taken to the scar on the east side of Staithes, a world-renowned geological location.

Associated Sites

Boulby Alum Quarries (SSSI, Other reference no. 54);
Loftus Alum Quarries (SSSI, Other reference no. 53).
Hummersea (Other reference no. 51).

Safety Information

WARNING: When going along the scar it is imperative to be aware of the tide times and the sea conditions, the sea reaches the cliff foot at high water and the uneven nature of the scar here makes the tide’s inward progress difficult to predict.

The scar is likely to be wet and slippery and there is danger of falling rock from the unstable cliffs. Please remain at least 10 metres from the cliff foot at all times.

A boulder field makes going west beyond Hole Wyke difficult and further westerly progress should be avoided.

Disclaimer: Tees Valley RIGS Group cannot be responsible for the safety of anyone visiting this coastal site. The accompanying map was accurate when this trail was devised in 2011, but these cliffs are prone to landslip through natural processes and paths may be lost.

A NOTE ON FOSSILS

Please feel free to collect loose fossil specimens weathered from their places of original deposition. However, to enable future scientific study, and for the enjoyment of others who may follow in your footsteps, in situ fossils (i.e. those still embedded in their position of original deposition) should not be collected, but their positions noted and details passed on to TVRIGS, a local museum or other similar body.

Please follow the Countryside Code. Do not light fires. Take any litter home.

Supplementary Information

Geology

Structure: The succession is shown in the cross-section. The beds dip at a slight angle to the east at Cowbar Nab and then swing to a more southerly direction at Boulby and beyond with the result that, going westwards from Cowbar Nab, one is gradually descending the Redcar Mudstone Formation succession.

Section through Boulby Cliff showing the dip of the beds to the south.

Whitby Mudstone Formation (marine, in part anoxic): The Hard and Mulgrave Shale Members are present high up in Boulby Cliff. Fallen blocks, mainly of calcareous and sideritic nodules, can be examined on the scar.

Cleveland Ironstone Formation (shallow marine, even shoaled, oxidic, ironstone formed under slow sedimentation): The various ironstone seams can be seen high in the cliff face below Boulby Quarry and particularly the Pecten and Main Seams. Measured sections were made by various geologists using the tracks down to the beach (e.g Bewick, 1861, Chowns, 1968).

Staithes Sandstone Formation (shallow marine, with tidal influences and storm surges) This forms the main part of Cowbar Nab and the lower part of the cliffs westwards. It is about 25m in thickness and consists principally of siltstones and fine-grained sandstones. Beds 1 to 10 of Howarth’s (1955) sequence of 23 beds are accessible on the west side of the harbour and the remainder on the scar to the east. Measured sections are recorded by Tate and Blake (1876, referred to as ‘Colburn Nab’) and Barrow (1888). Modern detailed descriptions are available by, for example, Howarth (ibid), Howard (1985), Knox et al. (1990, Figure 21), Rawson and Wright (1995, Fig. 22) and Hesselbo and Jenkyns (1995, Figures 25 & 26).

Rawson and Wright (ibid) reported that, as seen at Cowbar Nab;

"the dominant lithology in the lower beds is an intensively bioturbated, argillaceous silty sandstone, with occasional thin (1-35 cm), almost unbioturbated fine sandstones. The latter exhibit delicately-preserved bedding structures, including parallel lamination, low-angle cross-lamination and wave ripple lamination. They have erosive bases, sometimes down-cutting to form small channels".

Knox et al. (ibid) comment that the beds form;

"a fining-up sequence of intensely bioturbated sandy siltstones and siltstones containing laterally discontinuous scour-like tempestites".

Fossils are mostly restricted to shelly lenses.

According to Hesselbo and Jenkyns (ibid) individual beds (and particularly the basal ‘Oyster Bed’) can be correlated closely with those exposed at Robin Hood’s Bay.

Redcar Mudstone Formation (marine): At Cowbar Nab the sequence is transitional and the top of the Formation is taken arbitrarily at the base of the ‘Oyster Bed’ (c.30 cm thick). The 20m logged sequence at Cowbar Nab (Knox et al. ibid, Hesselbo and Jenkyns ibid, their figure 25) consists of silty mudstone passing up to muddy siltstone with graded layers and very fine-grained sandstone with the ‘Oyster Bed’ at the top. Bed 21 (in Hesselbo and Jenkyns log at 20m below the ‘Oyster Bed’) is an ooidal ironstone also seen at a similar level in Robin Hood’s Bay and drawn to their attention by J. Senior. Tate and Blake (ibid) also refer to, what may be the same, ooidal ironstone, 8 or 9 inches (~0.2m) thick at Red Nab and Barrow to a ‘white ironstone’ 40 feet 6 inches (12.3m) below the ‘Oyster Bed’.

Chronostratigraphy (from Hesselbo and Jenkyns ibid):

• Staithes Sandstone Formation (Prodactylioceras davoei zone, Oistoceras figulinum subzone (22m), Androgynoceras capricornus subzone (~2m at base).
• Redcar Mudstone Formation (Prodactylioceras davoei zone, Androgynoceras maculatum subzone).

Fossils lists specific to these localities are in Tate and Blake (ibid) and Barrow (ibid) but note that most have since been renamed.

Geomorphology: For about 2 km west of Cowbar Nab, where the cliffs are capped by till, marine erosion consists of a combination of gradual wearing away of material giving rise in particular to a notch just above high water mark, with more substantial joint/fault/bedding-controlled fracturing resulting in rockfalls, and landslippage of the much less coherent till (Agar, 1960, Hemingway, 1982). Slight variations in competence and fracture patterns have resulted in the formation of several small coves and nabs.

Further west, below the higher Boulby Cliffs, there have been several landslips and rockfalls reported during and since the period of alum working that have carried away parts of the works and particularly the tracks down to the shore. Elsewhere, such as, for example, at the western end of the alum quarry (Sallow Tree Plain) the cliff erosion has been limited at least for the past 150 years.

The ground between the Boulby and Loftus Quarries illustrates how the original cliffs may have looked.

The erosion has been studied in recent years by D. Pybus (see Appleton, 2010) and a team from Durham University.

Historical geology: These sea cliffs and Boulby Quarry above are where several 19^th Century and, since then, other geologists haves made measured sections, making use of the tracks down to the shore. That by Louis Hunton (1836) is the most notable as he was one of the first to recognize the importance of collecting fossils in situ and relating the fossils found to the beds in which they occur.

View of the cliffs looking west from Sandy Wyke. Redhouse Nab can be seen slightly left of center.

Industrial History and Archaeology

Alum: The alum works dates from the 1650s. It closed in 1871. The alum house was at NZ 761 190 on the cliff top. There was a liquor conduit from the quarries and tracks and a shaft and tunnel from the house down to the dock at Hole Wyke (see section on Boulby Quarry). The history and industrial archaeology of the alum works has received much attention in recent years.

The tunnel entrance was lost to view for many years owing to landslippage and was rediscovered by Owen (1990) when it reappeared as a result of the eventual erosion of the loose, landslipped material. Owen and others (especially Morris and Whitlock, 2005) have made detailed surveys as more of the archaeology has been revealed. The entrance and associated ‘rooms’ have now been largely lost to the sea and the real start of the tunnel in bedrock is now revealed.
The microbiology of adjacent weathered shale has been studied by Cockell et al., 2011.

Western tunnel in the cliff at Hole Wyke, beneath the former Alum House as seen on 11th March 2007.

Ironstone: The Main Seam of the Cleveland Ironstone Formation has been worked extensively from:

1. Boulby Mine (1903-1934), miners’ drift entrance at NZ 754 191, and
2. Grinkle Mine (1865-1934) drift at NZ 762 177.
   (Boulby ironstone mine main haulage drift is now under the surface buildings of Cleveland Potash mine and the fan shaft is near the railway at NZ 757 179).

The Main Seam typically consisted of a Top Block ~1m, Shale 0.3m and Bottom Block 0.7m. Waste was tipped in to the sea from a drift exit on the sea cliff at NZ 762 190.

It is likely that there was some earlier ironstone working involving the collection of material from the beaches; 2 drifts in the cliff face are shown by the Geological Survey (Yorkshire sheet IX, 1878) at approximately NZ 753 194 and 755 196).

Current mining: Cleveland Potash mine (at NZ 762 184) is of major importance to the local and national economies. Production started in 1973 and production is of the order 1 million tonnes per year of potash as well as common salt. The workings extend over a wide area that includes Boulby Quarry at a depth of around 1100m below sea level.

The discharge tunnel shaft is on the cliff top at NZ 765 190.

Bibliography

Maps

Geological Survey Yorkshire Sheet IX SW, Rockcliff. scale 6 inches to 1 mile, 1878 (Ordnance Survey 1856).
Notes on the Lower Lias, Main Seam and Dogger. 13 Steeping pits at Sallow Tree with cisterns, various buildings and reservoirs. Rockcliff (Pithill) building shown with various paths and reservoirs.

Geological Survey Yorkshire Sheet IXX NW, Boulby, Runswick & Kettleness scale 6 inches to 1 mile, 1899 (Ordnance Survey 1856).
Detailed layout plan of alum house.

Geology & Geomorphology

Agar, R. 1960. Post-glacial Erosion of the North Yorkshire Coast from the Tees Estuary to Ravenscar. Proc. Yorks. Geol. Soc., 32, 409-428.
A valuable study of coastal erosion but subject to much, perhaps mistaken, criticism by Hemingway and others.

Appleton, A. 2010. The Ice Age and its Aftermath in Eastern Yorkshire: One possible interpretation of the evidence. Unpublished review, 33p. (in Whitby Lit. and Phil. Library).
An important contribution collating many views on the ice age and including data on marine erosion.

Barrow, G. 1888. The Geology of North Cleveland. Mem. Geol. Survey, H.M.S.O., London, 101p.
Pages. 9 and 12 show the Redcar Mudstone and Staithes Sandstone Formation sequences.

Bewick, J. 1861. Geological Treatise on the District of Cleveland in North Yorkshire, etc. Reid, Newcastle-upon-Tyne, 194p.
Page 191 shows the measured ironstone section.

Chowns, T. M. 1968. Environmental and diagenetic studies of the Cleveland Ironstone Formation in north-east Yorkshire. Thesis, University of Newcastle upon Tyne.
Page 337 has the measured section at Rockcliff.

Cockell, C. S. et al. 2011. Molecular characterization and geological microenvironment of a microbial community inhabiting receding shale cliffs. Microb. Ecol. , 61, 166-181. Samples taken from shale in the alum tunnel.

Fox-Strangways, C. 1892. The Jurassic Rocks of Britain, Volume 1. Yorkshire. Geol. Survey, H.M.S.O., London, 551p.
Similar to Barrow, 1888.

Hemingway, J. E. 1982. Chapter 1 in Prehistoric and Roman archaeology of north-east Yorkshire ed. D.A. Spratt. BAR British Series 104, 7-31.
A useful account of the eminent professor’s views on glaciation, cliff erosion, etc.

Hesselbo, S. P. And Jenkyns, H. C. 1995. A comparison of the Hettangian and Bajocian successions of Dorset and Yorkshire. From Taylor, P. D. (ed.), Field geology of the British Jurassic, Geological Society, London, 105-150.
Very detailed account. Includes lithic logs of ~20m of the Redcar Mudstone Formation, Ironstone Shale and all the Staithes Sandstone Formation at Staithes (page 138). They report long distance correlation of individual beds, for example, with those at Robin Hood’s Bay and, incredibly, Dorset.

Howard, A. S. 1985. Lithostratigraphy of the Staithes Sandstone and Cleveland Ironstone Formations (Lower Jurassic) of north-east Yorkshire. Proc. Yorks. Geol. Soc. 45, 261-275.
Detailed description, classificationand mode of formation.

Knox, R. W. O’B, Howard, A.S., Powell, J. H. And van Buchem, F. S. P. 1991. Lower and Middle Jurassic Sediments of the Cleveland Basin N. E. England: shallow marine and paralic facies seen in their sequence stratigraphic context. Field guide no. 5, 13th International Sedimentological Congress, Nottingham. 66p.
Day 2 (at Staithes) covers Cowbar Nab including ~6m of the Redcar Mudstone Formation.

Rawson, P. F. and Wright, J. K. 1995. Jurassic of the Cleveland basin, North Yorkshire. From Taylor, P. D. (ed.), Field geology of the British Jurassic, Geological Society, London, 173-208.
Excursion 5 covers Cowbar Nab.

Rawson, P. F. and Wright, J. K. 2000. The Yorkshire Coast. Geologists’ Association Guide No. 34, 3rd revised edition., 130p.
Itinerary 1, Staithes to Port Mulgrave is on pages 16 to 24 and locality 1A is Cowbar Nab.

Tate, R. and Blake, J. F. 1876. The Yorkshire Lias. John Van Voorst, London, 475p.
Pages 89-101, especially page 97, detail the A. capricornus (now P. davoei) zone. Pages 132and 133 show the ironstone section as seen on the path to the shore.

Historical geology

Goldring, D. 2007. Louis Hunton and Loftus Alum Works. Cleveland Industrial Heritage No. 21, 9-15.
Includes a copy of Hunton’s famous section emphasising points of industrial interest.

Hunton, L. 1836. Remarks on a section of the Upper Lias and Marlstone of Yorkshire, etc. Trans. Geol. Soc. London, 5, 215-220.
This is Hunton’s classic paper and includes his section at Boulby, undoubtedly the best by the early 19th Century geologists.

Phillips, J. 1829. Illustrations of the Geology of Yorkshire, etc. Part 1: The Yorkshire coast. Private publication, York, 192p. (2nd Edition 1835 and 3rd Edition 1875, edit R. Etheridge).
Classic account. Section no. 9 shows some detail at Boulby.

Torrens, H. S. and Getty, T. A. 1984. Louis Hunton (1814-1838). English Pioneer in Ammonite Biostratigraphy. Earth Sciences History, 3, 58-68.
A biography stressing the scientific importance of Louis Hunton.

Young, G. and Bird, J. 1822. A Geological Survey of the Yorkshire Coast. Clark, Whitby, 332p. (2nd edition 1828).
The classic measured section at Boulby is on page 134 in the 2nd Edition with the Whitby Mudstone Formation divided into 3 units.

Industrial History & Archaeology

Alum

Barton, P. 2004. Boulby Alum Works: Ways down to the beach. CIAS Newsletter No. 86, 13.
Refers to R. Jackson’s journal items from 1757 to 1783.

Chapman, S. K. 1975. Excavations at the Boulby Alum Works. Cleveland Industrial Archaeology Soc., 2, 23-47.
One of the first industrial archaeological accounts of an alum works.

Chapman, K. 2002. Boulby Alum Works. Chapter 6 in Steeped in History (ed. Miller, I.), North Yorks Moors National Park Authority, 61-74.
A revised account of the 1975 work with major additions and maps by English Heritage.

Featherston, G. R. 2004. Boulby: More on ways down to the beach. CIAS Newsletter No. 86, 13-15.
Adds to Goldring, 2004. See also 18, 19 for photos by J. K. Almond dated 5/8/2004

Goldring, D. 2004. Boulby Alum Works. Ways down to the beach. CIAS Newsletter No. 85, 12,13.
Discussion of the two alum roads to the beach and the shaft and tunnel.

Goldring, D. 2006. Boulby Alum Tunnel. Cleveland Industrial Heritage no. 19, 20.
Brief description of tunnel seen in 2004.

Jecock, M. 2009. A Fading Memory: the North Yorkshire coastal alum industry in the light of recent analytical field survey by English Heritage. Industrial Archaeology Review, 31, 54-73.
General review of the alum industry, including several pictures of Boulby.

Morris, C. H. and Whitlock, S. 2005. Boulby Alum Works’ Tunnel Revisited. Cleveland Industrial Archaeologist No. 30, 29-45.
A detailed industrial archaeological appraisal based on visits between August 2004 and January 2005.

Owen, J. S. 1990. The Tunnel and Shaft for Boulby Alum Works, some features briefly exposed. CIAS Newsletter No. 51, 3-6.
Report on first exposure of the tunnel since being covered by a landslip for many years.

Owen, J. S. 1991. As above, CIAS Newsletter No. 53, page 6.

Owen, J. S. 1995. Continuing clearance at Boulby alum works beach tunnel. CIAS Newsletter No. 62, 3-6.
Further comments.

Owen, J. S. (CIAS Editorial Board). 1998. Cleveland Ironstone. A Memorial to John Owen. CIAS & NYMNP Authority, 103p.
Pages 81-84 are on the Boulby tunnel, etc. based on the CIAS Newsletter references.

Quinn, K. 2009. Boulby Alum. The works diary of George Dodds, 1772-1788. Cleveland Industrial Archaeology Society Research Report No. 9, 76p.
A detailed, primary historical account of operations at Boulby.

Ironstone

Chapman, S. 1997. Boulby Ironstone Mine. Peter Tuffs, Guisborough, 40p.
Account of ironstone mining at Boulby and description of surface remains.

Marley, J. 1857. Cleveland Ironstone, etc. North of England IME Trans., 165-219.
Early, 19th Century ironstone working.

Tuffs, P. 1996. Catalogue of Cleveland Ironstone Mines. Peter Tuffs, Guisborough, 56p.
General details of the mines; booklet (Cleveland Ironstone Series) specifically on Grinkle Mine to be published during 2011.

Abandonment Plans (at Teesside Archives)

Boulby (1 plan), abandoned 2/7/1934. Reference No. 11232

Grinkle (4 plans), abandoned 21/6/1934. Reference No. 11261

Surveyors

Denis Goldring 2011

Please Note: Tees Valley RIGS Group cannot be held responsible for the content of external sites.

©2011 Tees Valley RIGS Group.

1. Mini Geo-Trail
2. Geo-Trail Map
3. Directions
4. Bibliography

Mini Geo-Trail

In the following route description, notes concerned with navigation are show in plum, descriptions of features able to be seen are in black and warnings are given in red.

Geo-Trail Map

Hummersea mini geo-trail location map showing numbered features of interest and parking (P). Adapted from Along the Scar (2001) (See references).
(Click on map to enlarge)

Directions

• Car Park: On the west side of the Skinningrove Beck mouth at NZ 712 201. Cross the village front and go over the bridge to reach the slipway on the eastern side of the valley.
  
  

  Looking east from the car park across the beck mouth at Skinningrove showing Hummersea Cliff.

  1. There are views of the village, the slag cliffs topped by the iron and steelworks, the incline and the jetty used for the export of pig iron. Further afield, Huntcliff can be seen with the present day mineral railway and the Guibal fanhouse (a much better view is gained by going a little way up the Cleveland Way steps).

 



Looking west from Hummersea Scar showing the slag cliffs (center left), jetty and Cattersty Cliff (midground) and Huntcliff (background).

• Go on to the beach and eastwards on the scar.
  2. The cliff line follows the strike (i.e. the beds are apparently horizontal as seen) and the same strata can be followed for some distance. The ironstone seams gradually appear as the cliffs become higher with the Main Seam at c.60m. At scar level the Redcar Mudstone Formation, silty shale, has thin beds and nodules of ironstone. Rounding Hummersea Point there are two deep clefts in the cliffs, the result of jointing and faulting. There are good examples of rutways on the scar.

 




Members of the RIGS Group and others explore the perched boulders between Skinningrove and Hummersea Steps.

• Continue on to Hummersea Beach, the steps and the ‘kiln’.
  3 The various remains of alum operations noted above can be viewed and the variety of pebbles appreciated.

 




Members of the RIGS Group and others discuss Hummersea Cliff from the beach below Hummersea Steps.

• Continue on the usually wet scar to the Old Gut.
  4. The remains of the dock can be investigated and the ironstone seams of the landslip.The seams have an apparent dip of c.80º to the south! The old line of a track up the cliff can be made out.
  Warning: It’s possible for the intrepid to go on eastwards a short way and, perhaps, find the ‘third dock’ but beware of the incoming tide; there is no easy way up the cliff short of Staithes.

 

• Return to Hummersea Beach and climb the steps and path to the Cleveland Way.
  5. View the geomorphology of this area (much of which has now been donated to Tees Valley Wildlife Trust). The scarp line of Saltwick Sandstone is set back from the coast and is paralleled underground by the subcrop of the Cleveland Ironstone Formation (see the geological map). The, therefore, deep embayment is infilled by till that is much landslipped on the seawards side. The Snilah Ponds, still shown on modern maps, are said to have been infilled by material from Boulby Potash Mine development.

 




View of Hummersea Cliff and Scar (foreground) with Skinningrove Beck mouth and Cattersty Cliff (beyond). The swing in the strike of the beds on the scar is clearly seen. Warsett Hill and Hunt Cliff are in the background with the Guibal fanhouse visible on the cliff top

• Return to Skinningrove along the cliff top following the Cleveland Way. Hummersea House, the home of the Louis Hunton, the famous geologist, is in view to the south-west prior to rounding Warsett Hill.

Disclaimer: Tees Valley RIGS Group cannot be responsible for the safety of anyone visiting the Hummersea site whilst following this geo-trail. The accompanying map was accurate when this trail was devised in 2011, but these cliffs are prone to landslip through natural processes and paths may be lost.

THINK SAFETY

We suggest that you check tide times and weather conditions before setting off, and do so only on a falling tide. Take great care and remain at least 10m away from the cliff base as the cliffs are prone to rock falls. Use appropriate safety equipment where necessary.

Bibliography

See Hummersea site description page »

©2011 Tees Valley RIGS Group.

PLEASE NOTE: Tees Valley RIGS Group cannot be held responsible for the content of external sites.

1. Site Description
2. Geology
3. Access
4. General Assessment:
5. Associated Sites
6. Safety Information
7. Supplementary Information
8. Geology
9. Industrial History and Archaeology
10. Literature References
11. Maps & Plans
12. Surveyors

Site Description

Grid Reference: NZ 755 195
BGS Sheet: 34
OS Sheet: 94
Forwarded as RIGS: 30/09/2003

Site Status: SSSI (RIGS Site Ref: RC5, Site No. 54 [ * Under Review * ]). Open access.

Please Note: The quarry is situated on private land, however spectacular views can be found by walking along the Cleveland Way and other adjacent public footpaths.

Description of Geodiversity: Extensive former alum quarry of great geological, scientific, historical and industrial archaeological interest. The Cleveland Way passes around the southern edge and along the top of the quarry back-wall that rises to over 200m O.D. The coastal scenery is impressive.

View of Boulby Quarries (foreground) showing Cowbar Nab near Staithes (background). Taken from the Cleveland Way above Sallow Tree Plain.

Geology

The quarries form the upper part of a virtually complete Jurassic succession ranging from the Lower Jurassic Redcar Mudstone Formation on the foreshore to the Middle Jurassic Saltwick Formation at the top. The quarried beds of interest to the alum industry constitute principally the Alum Shale Member of the Whitby Mudstone Formation. The beds exposed in the quarries are:

• Saltwick Formation: This forms the southern back-wall of the quarry, some 600m in length and up to 30m in height. It is formed predominantly of river channel sandstones. These exposures are difficult to reach and best examined more closely within the numerous fallen blocks.
• Dogger Formation: This Formation is about 1m thick and consists mainly of siliceous ironstone. It is sometimes absent as a result of washouts, and is now poorly exposed.
• Alum Shale Member: There are good exposures of the lower beds of shale (Whitby Mudstone Formation) which form the quarry floor especially at the western end.
• Reasons for SSI Status: Although the SSSI is named Boulby it actually includes both Boulby and Loftus Quarries. Two significant features, the murchisonae shale facies of the Dogger Formation and the finding of pterosaur remains in the Alum Shale, are at Loftus Quarries but it is likely that other reptilian remains were also found at Boulby.

Geomorphology: Several past and potential landslips and rockfalls can be seen and, in contrast, examples of slow, gradual sub-aerial cliff erosion.

Historical geology: This is the site of 19^th century measured sections by Rev. George Young, John Phillips, Lewis Hunton and others.

Industrial Archaeology:

• The quarry was a major alum site with at least two stages of development – mid-17^th to late-18^th century and late-18^th to late-19^th centuries. Across the site can be found the remains of calcining places, steeping pits, buildings, reservoirs, liquor conduits, etc. The stone revetments at the western end are most impressive.
• There are small ironstone trials of the Top Seam (Dogger Formation).
• The quarry is underlain by the extensive underground workings of the Main Seam (Cleveland Ironstone Formation) that are exposed along the sea cliff face.

Access

Access map for Boulby Quarries showing extent of SSSI and suggested parking.
(Click on map to enlage)

The easiest access is from the east along the Cleveland Way. A minor road off the A174 affords suitable parking.

General Assessment:

The quarry is an excellent venue for demonstrating Lower and Middle Jurassic geology, recent geomorphology, historical geology and industrial archaeology (alum and ironstone workings). The high cliffs require care.

Associated Sites

Boulby Sea Cliffs and Foreshore (North Yorkshire Heritage Coast, RC5, other reference 80.);
Loftus Alum Quarries (SSSI, other reference no. 53).

Safety Information

PLEASE NOTE: Due to the presence of high unfenced cliff faces we suggest that this site is not suitable for visits by unsupervised children. Please remain well away from the cliff edge and ensure any dogs are kept on a lead. Because of their unstable nature these cliffs must not, under any circumstances, be climbed.

Please follow the Country Code. Do not light fires. Take any litter home.

In situ fossils must not be collected, but their positions noted and details passed on to TVRIGS, a local museum or other similar body. Scattered fossils already weathered from the rock may be collected freely.

Supplementary Information

Geology

Structure: The succession is shown in the accompany section. The beds dip about 3° to the south.

Section through the cliff and quarry demonstrating the gentle dip of the beds.

Saltwick Formation (deltaic/alluvial): This forms the impressive back-wall of the quarry and consists principally of massive lenses of river channel sandstone. It is generally difficult to reach owing to fallen rock. Blocks, some extremely large, can be readily examined showing sedimentary structures such as cross-bedding and the imprints of plant remains.

Dogger Formation (marine incursion): This is about 1m in thickness and consists mainly of siliceous ooidal ironstone. However, at the eastern end it is described as ooidal siderite mudstone overlain by dark mudstone with similar mudstone nodules, as a clear result of lateral transition (Rastall and Hemingway, 1940). It is now poorly exposed. Blocks of ironstone can be examined that form a roughly laid wall by an old trial adit.

Alum Shale Member (marine): Some 10m of beds are exposed at various sub-quarry levels especially at the western (Sallow Tree Plain) end of the workings around the stone revetments. They consist of weathered, friable, grey, iron-stained, poorly bedded, flaky shale with vertically disposed jointing on the small scale. Fossils, chiefly poorly preserved belemnites, are uncommon but when seen may be present in clusters. Small acicular crystals of iron-stained gypsum are common. Occasional beds of lighter grey, calcareous, sometimes septarian, nodules can be found but, so far, Howarth’s (1962) detailed lithostratigraphic succession has not been elucidated. It is likely that the beds exposed belong to the lower part of the Alum Shale Member (the Hard Shale sub-unit) or even the upper part of the Mulgrave Shale Member.

Revetment walls at the west end of the site with Cowbar Nab in the background.

Geomorphology: The back-wall of the quarry has been subject to rock falls and there is now much debris at its foot. At the top, on the Cleveland Way there are open fissures with the cliffs being in a poor state. At quarry level on the seawards side there have been several landslips reported during and since the period of working that have carried away parts of the alum works and particularly the former tracks down to the shore. Elsewhere, such as for example at the Sallow Tree Plain (western end) steeping pits the cliff erosion has been limited. The ground between the Boulby and adjacent Loftus Alum Quarries illustrates how the original cliff profile looked.

Historical geology: Boulby Quarry and the sea cliffs beneath (making use of the tracks down to the shore) are where several 19^th century and, more recently, geologists such as Chowns made measured sections. That by Lewis Hunton (1836) is the most notable as he independently recognized the importance of collecting fossils in-situ, and relating the fossils found to the beds in which they occur bolstering the emerging concept of biostratigraphy.

View of Boulby Quarry and cliff as seen from Bias Scar toward Staithes.

Industrial History and Archaeology

Alum: The alum works was started in the 1650s at the eastern (Rockhole Hill) end of the quarry, redeveloped at the western (Sallow Tree Plain) end in 1784, and eventually closed in 1871. The alum house was about 0.5km to the south-east and, as well as tracks, there was a shaft and tunnel here connecting the house to the dock at Hole Wyke (see Boulby Sea Cliffs and Foreshore). The history and industrial archaeology of the alum works has received much attention in recent years (see references).

Ironstone: The Main Seam of the Cleveland Ironstone Formation has been worked extensively under the quarries from:

• (a) Boulby Mine, miners’ drift entrance at NZ 754 191, and
• (b) Grinkle Mine drift at NZ 762 177.

Boulby Ironstone Mine main haulage drift is now under the surface buildings of Cleveland Potash Mine, and the fan shaft is near the railway at NZ 757 179. The Main Seam typically consisted of a Top Block ~1m, Shale 0.3m and Bottom Block 0.7m. Waste was tipped in to the sea from a drift exit on the sea cliff at NZ 762 190. There are two trials of the Top Seam ironstone of the Dogger Formation, one within the quarries and one a short distance to the east (at NZ 758 190).

Current mining: Cleveland Potash Mine (at NZ 762 184) is of major importance to the local and national economies. Production started in 1973 and is of the order 1 million tonnes per year of potash (sylvinite) as well as rock salt (halite). The workings extend over a wide area that includes Boulby Quarry at a depth of around 1100m below sea level.

Literature References

Maps & Plans

Geological Survey Yorkshire Sheet IX SW, Rockcliff, scale 6 inches to 1 mile, 1878 (Ordnance Survey 1856).
Notes on the Lower Lias, Main Seam and Dogger. Shows 12 Steeping pits at Sallow Tree with cisterns, various buildings and reservoirs. Rockcliff (Pithill) building shown with various paths and reservoirs.

Geological Survey Yorkshire Sheet IXX NW, Boulby, Runswick & Kettleness, scale 6 inches to 1 mile, 1899 (Ordnance Survey 1856).
Shows outline plan of the alum house.

Ironstone Abandonment Plans (at Teesside Archives)

Boulby (1 plan), abandoned 2/7/1934. Ref. 11232
Grinkle (4 plans), abandoned 21/6/1934. Ref. 11261

Barrow, G. 1888. The Geology of North Cleveland. Mem. Geol. Survey, H.M.S.O., London, 101p.
Official memoir. Page. 9 shows the Main Seam ironstone section made on ‘the old road now slipped away’. Pages 42 and 43 show Dogger sections.

Chapman, S. K. 1975. Excavations at the Boulby Alum Works. Cleveland Industrial Archaeology Soc., 2, 23-47.
One of the first industrial archaeological accounts of an alum works.

Chapman, S. 2005. Boulby Alum Works Visit. C.I.A.S Newsletter No. 88, 11-17.
Industrial archaeological excursion guide.

Chapman, K. 2002. Boulby Alum Works. Chapter 6 in ‘Steeped in History’ (ed. Miller, I.), North Yorks Moors National Park Authority, 61-74.
A revised account of the 1975 work with additions and maps by English Heritage.

Fox-Strangways, C. 1892 The Jurassic Rocks of Britain, Volume 1. Yorkshire. Geol. Survey, H.M.S.O., London, 551p.
Similar to Barrow, 1888.

Goldring, D. 2001. Along the Scar. Peter Tuffs, Guisborough, 145p.
See pages 59 to 65.

Goldring, D. 2007. Louis Hunton and Loftus Alum Works. Cleveland Industrial Heritage No. 21, 9-15.
Includes a copy of Hunton’s famous section emphasising points of industrial interest.

Hunton, L. 1836. Remarks on a Section of the Upper Lias and Marlstone of Yorkshire, etc. Trans. Geol. Soc. London, 5, 215-220.
This is Hunton’s classic paper and includes his section at Boulby, undoubtedly the best by the early 19th Century geologists.

Jecock, M. 2009. A Fading Memory: The North Yorkshire coastal alum industry in the light of a recent analytical field survey by English Heritage. Industrial Archaeology Review, 31, 54-73.
General review of the alum industry, including several pictures of Boulby.

Marley, J. 1857. Cleveland Ironstone, etc. North of England IME Trans., 165-219.
Early, 19th Century ironstone working.

Miller, I. 2002. Steeped in History North York Moors NPA.

Osbourne, R. 1998. The Floating Egg Pimlico.

Phillips, J. 1829. Illustrations of the geology of Yorkshire, etc. Part 1 The Yorkshire coast. Private publication, York, 192p. (2nd Edition 1835 and 3rd Edition 1875, edit R. Etheridge).
Classic account. Section no. 9 shows some detail at Boulby.

Quinn, K. 2009. Boulby Alum: The works diary of George Dodds, (1772-1788). Cleveland Industrial Archaeology Society Research Report No. 9, 76p.
A detailed, primary historical account of operations at Boulby.

Rastall, R. H. & Hemingway, J. E. 1940. The Yorkshire Dogger, 1. The Coastal Region. Geol. Mag., 77, 177-197 & 257-275.
This is the only detailed description of the Dogger Formation for the Cleveland area. Pages 191 and 192 refer to Boulby sections and pages 263 and 264 to the petrography.

Tate, R. and Blake, J. F. 1876. The Yorkshire Lias. John Van Voorst, London, 475p.
Pages 132 and 133 show the ironstone section as seen on the path to the shore. Pages 170 and 175 detail the section in part of the Whitby Mudstone Formation.

Torrens, H. S. and Getty, T. A. 1984. Louis Hunton (1814-1838). English Pioneer in Ammonite Biostratigraphy. Earth Sciences History, 3, 58-68.
A biography stressing the scientific importance of Louis Hunton.

Tuffs, P. 1996. Catalogue of Cleveland Ironstone Mines. Peter Tuffs, Guisborough, 56p.
General details of the mines.

Young, G. and Bird, J. 1822. A Geological Survey of the Yorkshire Coast. Clark, Whitby, 332p. (2nd edition 1828).
The classic measured section at Boulby is on page 134 in the 2nd Edition with the Whitby Mudstone Formation divided into 3 subdivisions.

Surveyors

Denis Goldring 2011

©2011 Tees Valley RIGS Group.

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 7784 192
BGS Sheet 34
OS Sheet 94
Forwarded as RIGS Part of Skinningrove to Staithes Coast 30/09/2003

Site Description

Site Status Part of the Heritage Coast
Description of Geodiversity Costal cliff nab exposure consisting of the Staithes sandstone formation which is the type locality. The foreshore to the west of the coastal defences consists of Redcar mudstone
Literature References The Yorkshire Coast – Peter Rawson & John Wright 1992
The Regional Coastline of Yorkshire – J.W.Steers 1967

Site Map

Site Assessment

Surveyors

Andrew Carter, Andrew Cooper, Carl Rees-Davies

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 655 200
BGS Sheet 34
OS Sheet 94
Forwarded as RIGS Part of Skelton beck 30/09/03

Site Description

Site Status SNCI
Description of Geodiversity Stream bed and river-cliff exposures of Staithes sandstone. Natural waterfall. Change of facies to Cleveland ironstone
Literature References

Site Map

Site Assessment

Surveyors

Andrew Carter, Andrew Cooper

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 622 148
BGS Sheet 34
OS Sheet 94
Forwarded as RIGS Part of Guisborough Forest 30/09/2003

Site Description

Site Status SNCI
Description of Geodiversity North facing escarpment revealing few exposures. Underlying geology is Staithes sandstone, Cleveland ironstone, Whitby mudstone overlain by the Saltwick sandstone formation. Old mine tips now wooded
Literature References Guisborough District Mines – Simon Chapman 2001
The Floating Egg – Roger Osbourne 1998

Site Map

Site Assessment

Surveyors

Denis Goldring

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 690 228
BGS Sheet 34
OS Sheet 94
Forwarded as RIGS Part of Saltburn to Skinningrove Coast 30/09/2003

Site Description

Site Status SNCI
Description of Geodiversity Wave washed platform and cliffs revealing Redcar mudstone formation at the base overlain by Staithes sandstone in the cliffs. Cleveland ironstone in upper part of cliffs, all capped by glacial till
Literature References Along the Scar – Denis Goldring 2001
The Regional Coastline of Yorkshire – J.W.Steers 1967

Site Map

Site Assessment

Surveyors

Denis Goldring

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 663 202
BGS Sheet 34
OS Sheet 94
Forwarded as RIGS Part of Skelton Beck 30/09/03

Site Description

Site Status SNCI
Description of Geodiversity Steep sided gorge revealing exposures of Staithes sandstone with a small natural waterfall
Literature References

Site Map

Site Assessment

Surveyors

Andrew Cooper

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 577 124
BGS Sheet 34
OS Sheet 93
Forwarded as RIGS Part of Roseberry Topping 30/09/2003

Site Description

Site Status SSSI and SNCI
Description of Geodiversity Escarpment crags of Staithes sandstone
Literature References Yorkshire Rocks and Landscapes – YGS 1984

Site Map

Site Assessment

Surveyors

Andrew Carter, John Waring

1. Site Description
2. Site Map
3. Site Assessment
4. Surveyors

Grid Reference NZ 588 196
BGS Sheet 34
OS Sheet 93
Forwarded as RIGS Part of Eston Hills 30/09/03

Site Description

Site Status SNCI
Description of Geodiversity Streamside river-cliff exposure of Staithes sandstone. Smaller exposures are available around location
Literature References The Geology of Eston Hills – R&CBC 1998

Site Map

Site Assessment

Surveyors

Andrew Carter, John Waring